钢桥面板顶板与纵肋连接疲劳开裂局部加固分析
PDF下载 (238)杨靖男,朋 茜,孙义斐.钢桥面板顶板与纵肋连接疲劳开裂局部加固分析[J].宁波大学学报(理工版),2023,36(2):42-49.DOI:
YANG Jingnan,PENG Xi,SUN Yifei.Partial reinforcement effect of fatigue cracks in rib-to-deck joints of orthotropic steel decks[J].Journal of Ningbo University(Natural Science & Engineering Edition),2023,36(2):42-49.DOI:
| Title: | Partial reinforcement effect of fatigue cracks in rib-to-deck joints of orthotropic steel decks |
| 作者: | 杨靖男, 朋 茜, 孙义斐 |
| Author(s): | YANG Jingnan, PENG Xi, SUN Yifei |
| 关键词: | 桥梁工程; 正交异性钢桥面板; 疲劳加固; 扩展有限元法 |
| Keywords: | bridge engineering; orthotropic steel deck; fatigue reinforcement; extended finite element method |
| 分类号: | U441 |
| 文献标识码: | A |
| 摘要: | 正交异性钢桥面板纵肋与顶板连接细节处极易产生疲劳裂纹. 本文通过精细化有限元模型, 分析了栓接角钢加固法和粘贴纤维增强复合材料(Fiber Reinforced Polymer, FRP)型材加固法对钢桥面板疲劳性能的影响. 结果表明: 采用角钢、FRP型材对顶板与纵肋连接细节的疲劳裂纹进行加固, 焊缝裂纹附近热点应力峰值降幅可达56.2％和46.5％; 焊缝裂纹尖端附近应力强度因子随着板件整体尺寸的增大而减小; 改变板件厚度对应力强度因子结果值影响最大, 最高可使其下降约80％, 改变板件纵向长度和单肢长度对其有一定影响; 随着裂纹的持续扩展, 栓接角钢法的加固效果开始下降. 建议在监测到构造细节处疲劳裂纹后应尽早加固. |
| Abstract: | The rib-to-deck joints of orthotropic steel decks are prone to fatique cracks. Through the establishment of finite element model, the influences on the fatigue performance by two approaches, bolting angle steel and pasting FRP profile of orthotropic steel decks, are analyzed. The results show that: the peak value of hot spot stress near weld crack decreases significantly by such two approaches. It can be reduced by 56.2％ by bolting angle steel, and 46.5％ by pasting prefabricated FRP profile. The stress-intensification factor near the tip of the weld crack decreases with the increase of the overall size of the plate, where the most influential factor is the thickness of the plate and the stress-intensification factor can be reduced by about 80％ at most. In addition, the longitudinal length and single limb length of the plate also have certain influence on it. As the crack propagates, the reinforcement effect by bolting angle steel begins to weaken. It is suggested that the reinforcement should be carried out as soon as possible when the fatigue cracks in the longitudinal rib-to-deck joints are monitored. |
| 参考文献 /References: | [1] 张清华, 李俊, 卜一之, 等. 正交异性钢桥面板纵肋与横隔板交叉构造细节疲劳开裂快速加固方法[J]. 中国公路学报, 2018, 31(12):124-133. [2] 张清华, 卜一之, 李乔. 正交异性钢桥面板疲劳问题的研究进展[J]. 中国公路学报, 2017, 30(3):14-30; 39. [3] 周绪红, 朋茜, 秦凤江, 等. 钢桥面板顶板与纵肋连接焊根位置疲劳损伤特征[J]. 交通运输工程学报, 2018, 18(1):1-12. [4] 曹雪坤, 傅中秋, 高玉强, 等. 钢桥面板顶板焊根裂纹对铺装层受力性能影响[J]. 三峡大学学报(自然科学版), 2022, 44(4):39-44. [5] 王洋, 邵旭东, 陈杰, 等. 重度疲劳开裂钢桥桥面的UHPC加固技术[J]. 土木工程学报, 2020, 53(11):92- 101; 115. [6] Wang Y Z, Wang C S, Duan L. Bonding and bolting angle reinforcement for distortion-induced fatigue in steel girder bridges[J]. Thin-Walled Structures, 2021, 166: 108027. [7] 王贤强, 杨羿, 刘朵, 等. 平板贯穿裂纹高强螺栓止裂加固试验研究[J]. 建筑结构, 2022, 52(3):104-109. [8] 吕志林, 姜旭, 强旭红, 等. 高弹模CFRP粘贴法修复钢桥板疲劳裂纹[J]. 建筑钢结构进展, 2022, 24(5):92-100. [9] 邓扬, 刘涛磊, 曹宝雅, 等. 钢桥面顶板-U肋焊缝表贴增强板材疲劳加固方法研究[J]. 中国公路学报, 2022, 35(2):201-211. [10] 徐伟伟, 祝志文, 牛华伟. 正交异性钢桥面板纵肋-面板疲劳开裂的CFRP加固研究[J]. 铁道科学与工程学报, 2021, 18(11):2933-2943. [11] 朱志伟, 高天, 吉伯海, 等. 基于现场监测的钢桥面板疲劳裂纹气动冲击修复效果评估[J]. 武汉理工大学学报(交通科学与工程版), 2022, 46(1):120-124. [12] 尤永学. 随机车辆荷载流下UHPC加固正交异性钢桥面板疲劳性能评估[J]. 城市道桥与防洪, 2022(3):182-185; 212. [13] Qin S Q, Zhang J B, Huang C L, et al. Fatigue performance evaluation of steel-UHPC composite orthotropic deck in a long-span cable-stayed bridge under in-service traffic[J]. Engineering Structures, 2022, 254:113875. [14] Cheng B, Abdelbaset H, Li H T, et al. Fatigue behavior of rib-to-floorbeam welded connections in UHPC reinforced OSDs subjected to longitudinal flexural[J]. Engineering Failure Analysis, 2022, 137:106383. [15] Kelly G. Load transfer in hybrid (bonded/bolted) composite single-lap joints[J]. Composite Structures, 2005, 69(1):35-43. [16] Wang B J, Zhou X Y, Chen A R. Probabilistic study on the macro-crack initiation of the rib-to-deck welded joint on orthotropic steel deck[J]. International Journal of Fatigue, 2020, 139:105721. |
| 备注/Memo: | 收稿日期: 2022－06－23. 宁波大学学报（理工版）网址: http://journallg.nbu.edu.cn/ 基金项目: 国家自然科学基金（52008215）; 浙江省自然科学基金（LQ20E080013）. 宁波大学学报（理工版）网址：http://journallg.nbu.edu.cn/第一作者: 杨靖男（1999－）, 男, 浙江嵊州人, 在读硕士研究生, 主要研究方向: 钢结构与组合结构桥梁. E-mail: yangjn1999@163.com *通信作者: 朋茜（1990－）, 女, 陕西商南人, 博士/副教授, 主要研究方向: 钢结构与组合结构桥梁. E-mail: pengxi@nbut.edu.cn |
