污泥基吸附剂对亚甲基蓝和环丙沙星的吸附性能研究
PDF下载 (1753)张凌霄,于 洁,吕 阳,王 洋,韩荣平,夏 晨,祝怡臻,朱振宇.污泥基吸附剂对亚甲基蓝和环丙沙星的吸附性能研究[J].宁波大学学报(理工版),2021,34(3):47-53.DOI:
ZHANG Lingxiao,YU Jie,L? Yang,WANG Yang,HAN Rongping,XIA Chen,ZHU Yizhen,ZHU Zhenyu.Adsorption of methylene blue and ciprofloxacin by activated sludge-derived adsorbent[J].Journal of Ningbo University(Natural Science & Engineering Edition),2021,34(3):47-53.DOI:
| Title: | Adsorption of methylene blue and ciprofloxacin by activated sludge-derived adsorbent |
| 作者: | 张凌霄, 于 洁, 吕 阳, 王 洋, 韩荣平, 夏 晨, 祝怡臻, 朱振宇 |
| Author(s): | ZHANG Lingxiao, YU Jie, L? Yang, WANG Yang, HAN Rongping, XIA Chen, ZHU Yizhen, ZHU Zhenyu |
| 关键词: | 活性污泥; 热解; 吸附; 亚甲基蓝; 环丙沙星 |
| Keywords: | activated sludge; pyrolysis; adsorption; methylene blue; ciprofloxacin |
| 分类号: | X705 |
| 文献标识码: | A |
| 摘要: | 亚甲基蓝和环丙沙星是水体中2种污染物, 对生态环境有潜在危害. 本文以市政剩余活性污泥为原料, 氯化锌为活化剂热解制备污泥基吸附剂, 研究盐酸酸洗浓度、氯化锌浓度、热解温度、热解时间等对污泥基吸附剂吸附水中亚甲基蓝和环丙沙星性能的影响. 结果表明 (1)污泥基吸附剂对亚甲基蓝的吸附性能随盐酸酸洗浓度的增大而增加, 对环丙沙星的吸附性能则随盐酸酸洗浓度的增大呈先降后增趋势, 两者均在1.500mol·L-1盐酸浓度下取得最优值. (2)污泥基吸附剂对亚甲基蓝和环丙沙星的吸附性能随氯化锌浓度和热解温度的增加呈先升后降趋势, 在氯化锌浓度为4.0mol·L-1、热解温度为500℃时有最优值; 随着热解时间的延长, 污泥基吸附剂对亚甲基蓝和环丙沙星的吸附性能分别在500℃热解70min和80min时有最优值. (3)污泥基吸附剂的最佳制备条件为 氯化锌4.0mol·L-1活化2h、500℃热解70min和80min、1.500mol·L-1盐酸酸洗; 以此制得的污泥基吸附剂对亚甲基蓝和环丙沙星的去除率分别为97.7%和96.4%, 平衡吸附量分别为97.9mg·g-1和3.9mg·g-1, 且污泥基吸附剂对亚甲基蓝和环丙沙星的吸附过程均符合准二级动力学方程. |
| Abstract: | Methylene blue and ciprofloxacin are common contaminants in the aqueous environment and have great potential hazards to the environment. An adsorbent was prepared in this study using municipal waste activated sludge as raw material, zinc chloride as activator, and pyrolysis as the main treatment unit. The adsorption of methylene blue and ciprofloxacin in water by the sludge-derived adsorbent were investigated. The results show that (1) The adsorption efficiency of methylene blue by the sludge-derived adsorbent increased with the increase of the pH level of the acid wash, while the adsorption efficiency of ciprofloxacin decreases firstly, and then increased, and the best performance of the sludge-derived adsorbent was obtained under 1.5mol·L-1 hydrochloric acid wash. (2) The adsorption efficiencies of methylene blue and ciprofloxacin by the sludge-derived adsorbent both showed first elevation and then reduction trends with the increase of zinc chloride concentration and pyrolysis temperature, and were optimized at 4.0mol·L-1 zinc chloride activation and 500℃ pyrolysis for 70 and 80min (for methylene blue and ciprofloxacin, respectively). (3) The optimized preparation procedure for the sludge-derived adsorbent was as follows activating the sludge with 4.0mol·L-1 zinc chloride solution for 2h, pyrolyzing at 500℃ for 70 min or 80min, and washing with 1.500mol·L-1 hydrochloric acid, achieving removal rates of 97.7% and 96.4% for methylene blue and ciprofloxacin, respectively, with equilibrium adsorption capacity of 97.9mg·g-1 and 3.9mg·g-1, respectively. The adsorption processes of methylene blue and ciprofloxacin by the sludge-derived adsorbent were well described by the pseudo-second order kinetic equation. |
| 参考文献 /References: | [1] 王婷. 剩余污泥基吸附剂吸附特性的研究[D]. 济南: 山东大学, 2016. [2] Chen T, Zhang Y X, Wang H T, et al. Influence of pyrolysis temperature on characteristics and heavy metal adsorptive performance of biochar derived from municipal sewage sludge[J]. Bioresource Technology, 2014, 164:47-54. [3] 贺自帅, 高红, 岳波, 等. 污泥吸附剂的制备及其应用[J]. 净水技术, 2020, 39(7):84-91. [4] Kah M, Sun H C, Sigmund G, et al. Pyrolysis of waste materials: Characterization and prediction of sorption potential across a wide range of mineral contents and pyrolysis temperatures[J]. Bioresource Technology, 2016, 214:225-233. [5] 李冰, 刘绍根, 倪丙杰, 等. 活性污泥生物吸附性能的研究[J]. 安徽建筑工业学院学报(自然科学版), 2006, 14(4):77-80. [6] 张珂, 郑宾国, 程文博, 等. 改性污泥活性炭吸附废水中Cr(Ⅵ)的性能研究[J]. 环境科学与管理, 2017, 42(9): 109-111. [7] Chiang Y W, Ghyselbrecht K, Santos R M, et al. Adsorption of multi-heavy metals onto water treatment residuals: Sorption capacities and applications[J]. Chemical Engineering Journal, 2012, 200/201/202:405-415. [8] 余兰兰. 污泥吸附剂的制备及应用研究[D]. 南京: 南京理工大学, 2006. [9] 徐炜. 一种处理印染废水中亚甲基蓝的方法: CN104276619A[P]. 2015-01-14. [10] 陈丽媛, 李大鹏, 朱文娟, 等. 污泥水热炭对亚甲基蓝的吸附特性[J]. 环境科学, 2020, 41(4):1761-1769. [11] 高豆豆, 郭敏辉, 王侃, 等. 城镇有机垃圾热解生物炭对水中亚甲基蓝的吸附[J]. 环境工程学报, 2019, 13(5): 1165-1174. [12] Gothwal R, Shashidhar T. Antibiotic pollution in the environment: A review[J]. CLEAN-Soil, Air, Water, 2015, 43(4):479-489. [13] Tong L, Li P, Wang Y X, et al. Analysis of veterinary antibiotic residues in swine wastewater and environmental water samples using optimized SPE- LC/MS/MS[J]. Chemosphere, 2009, 74(8):1090-1097. [14] Watkinson A J, Murby E J, Costanzo S D. Removal of antibiotics in conventional and advanced wastewater treatment: Implications for environmental discharge and wastewater recycling[J]. Water Research, 2007, 41(18): 4164-4176. [15] 陈小丽, 魏金华, 蔺中, 等. 抗生素的微生物降解研究进展[J]. 现代农业科技, 2018(16):167-168. [16] Qiao M, Ying G G, Singer A C, et al. Review of antibiotic resistance in China and its environment[J]. Environment International, 2018, 110:160-172. [17] 杨振宇. 生物炭吸附环丙沙星的作用机理研究[D]. 杭州: 浙江大学, 2019. [18] Movasaghi Z, Yan B, Niu C. Adsorption of ciprofloxacin from water by pretreated oat hulls: Equilibrium, kinetic, and thermodynamic studies[J]. Industrial Crops and Products, 2019, 127:237-250. [19] Wang K, Gao D D, Xu J R, et al. Interaction of ciprofloxacin with the activated sludge of the sewage treatment plant[J]. Environmental Science and Pollution Research, 2018, 25(35):35064-35073. [20] 张伟, 汪爱河, 蒋海燕. 硫酸活化市政污泥对亚甲基蓝的吸附[J]. 环境工程学报, 2015, 9(8):3790-3794. [21] 邵瑞华. 泥质活性炭的制备及污泥热解动力学研究[D]. 西安: 西安建筑科技大学, 2011. [22] Hadi P, Xu M, Ning C, et al. A critical review on preparation, characterization and utilization of sludge- derived activated carbons for wastewater treatment[J]. Chemical Engineering Journal, 2015, 260:895-906. |
| 备注/Memo: | 收稿日期:2020-09-12.宁波大学学报（理工版）网址:http://journallg.nbu.edu.cn/ 基金项目:宁波大学大学生科技创新计划项目（2020SRIP1415）. 第一作者:张凌霄（1995－）,女,江苏南通人,在读硕士研究生,主要研究方向:水污染控制.E-mail:810802695@qq.com *通信作者:于洁（1987－）,女,河南三门峡人,博士/副教授,主要研究方向:固体废物处理与资源化.E-mail:yujie@nbu.edu.cn 宁波大学学报（理工版）网址：http://journallg.nbu.edu.cn/ |
