非均相臭氧催化氧化对污泥脱水性能的影响
PDF下载 (388)郑洋洋,张凌霄,徐丹瑶,刘 婷,吴安诺,于 洁,郭敏辉.非均相臭氧催化氧化对污泥脱水性能的影响[J].宁波大学学报(理工版),2022,35(6):86-91.DOI:
ZHENG Yangyang,ZHANG Lingxiao,XU Danyao,LIU Ting,WU Annuo,YU Jie,GUO Minhui.Effect of heterogeneous catalytic ozonation on sludge dewaterability[J].Journal of Ningbo University(Natural Science & Engineering Edition),2022,35(6):86-91.DOI:
| Title: | Effect of heterogeneous catalytic ozonation on sludge dewaterability |
| 作者: | 郑洋洋, 张凌霄, 徐丹瑶, 刘 婷, 吴安诺, 于 洁, 郭敏辉 |
| Author(s): | ZHENG Yangyang, ZHANG Lingxiao, XU Danyao, LIU Ting, WU Annuo, YU Jie, GUO Minhui |
| 关键词: | 臭氧; 非均相; 催化; 污泥; 脱水 |
| Keywords: | FeOOH; ozonation; heterogeneous; catalyst; sludge; dewaterability |
| 分类号: | X705 |
| 文献标识码: | A |
| 摘要: | 臭氧氧化技术是一项具有应用前景的新型污泥减量技术, 但臭氧处理会导致污泥脱水性能恶化, 影响后续处理处置, 需要其他技术或手段的辅助以提高污泥脱水性能. 以市政剩余活性污泥为原料, 采用FeOOH、Fe2O3、TiO2、MnO2、Al2O3粉、Al2O3球、果壳活性炭、椰壳活性炭、粉质炭、煤质炭、铜丝等11种非均相催化剂开展污泥的非均相臭氧催化氧化实验, 研究污泥脱水性能的变化. 结果表明, 在11种非均相催化剂中, TiO2、Fe2O3、Al2O3球、铜丝、FeOOH、粉质炭能够显著抑制臭氧处理对污泥脱水性能的恶化作用, 其中FeOOH、粉质炭和铜丝效果最佳. 在FeOOH、粉质炭和铜丝催化臭氧氧化体系中, 22.50mg·L-1臭氧为较优浓度, 浓度过低或过高均不利于污泥脱水性能的改善. 3种催化剂中, FeOOH催化臭氧氧化对低含固率(0.5%和1%)污泥的脱水性能有明显的改善效果. FeOOH投加量的增加有利于在较短的反应时间内改善污泥的脱水性能. 向含固率为0.5%的污泥中投加300mg·g-1 DS FeOOH、37.95mg·L-1臭氧, 污泥的CST可在5min内下降21.1%. FeOOH催化臭氧氧化是一种有前景的强化污泥脱水性能的方法. |
| Abstract: | Ozonation is a promising technique for sludge minimization, but it also leads to the deterioration of dewaterability, hindering the subsequent treatment and disposal. To improve the sludge dewaterability, heterogeneous catalytic ozonation was adopted in this study, using 11 kinds of catalysts, including FeOOH, Fe2O3, TiO2, MnO2, Al2O3 powder, Al2O3 ball, nut shell activated carbon, coconut shell activated carbon, powdered activated carbon, coal based activated carbon, and copper wire The dewatering performance of sludge was evaluated. Results show that among the 11 catalysts, TiO2, Fe2O3, Al2O3 ball, copper wire, FeOOH, and powdered activated carbon could significantly inhibit the deterioration of sludge dewaterability caused by ozonation, and FeOOH, powdered activated carbon, copper wire performed the best. During ozonation treatment catalyzed by FeOOH, powdered activated carbon and copper wire, 22.50mg·L-1 was a suitable ozone dosage, and a higher or lower dosage was adverse to the improvement of sludge dewaterability. Among the 3 catalysts, FeOOH catalyzed ozonation could dramatically improve the dewatering performance of sludge with low solid content (0.5% and 1%). Increase of FeOOH dosage was beneficial to improve the dewatering performance of sludge in a short reaction time. The CST of the sludge (solid content 0.5%) reduced 21.1% in 5min when FeOOH (300mg·g-1 DS) catalyzed ozonation (37.95mg·L-1) was applied, suggesting that it is a promising method to enhance the sludge dewatering performance. |
| 参考文献 /References: | [1] 刘亚奇. 臭氧协同超声波对剩余污泥溶胞破解的实验研究[D]. 赣州: 江西理工大学, 2018. [2] 黄中林, 宫常修, 蒋建国, 等. Fenton氧化对污泥脱水性能和溶解性物质作用效果的研究[J]. 环境工程, 2012, 30(S2):573-576. [3] 林秀锋. 超声波联合典型吸附剂调理污泥脱水性能及其堆肥研究[D]. 兰州: 兰州理工大学, 2021. [4] Dong B, Liu X, Dai L, et al. Changes of heavy metal speciation during high-solid anaerobic digestion of sewage sludge[J]. Bioresource Technology, 2013, 131:152-158. [5] 张斯玮, 梁嘉林, 黄锦佳, 等. 缺氧酸化联合零价铁-过氧化氢改善污泥脱水性能的研究[J]. 环境科学学报, 2019, 39(3):780-789. [6] Cao B, Zhang T, Zhang W, et al. Enhanced technology based for sewage sludge deep dewatering: A critical review[J]. Water Research, 2021, 189:116650. [7] 甄广印, 吴太朴, 陆雪琴, 等. 高级氧化污泥深度脱水技术研究进展[J]. 环境污染与防治, 2019, 41(9):1108- 1113; 1119. [8] Fall C, Silva-Hernández B C, Hooijmans C M, et al. Sludge reduction by ozone: Insights and modeling of the dose-response effects[J]. Journal of Environmental Management, 2018, 206:103-112. [9] Yu J, Xiao K, Yang J, et al. Enhanced sludge dewaterability and pathogen inactivation by synergistic effects of zero-valent iron and ozonation[J]. ACS Sustainable Chemistry & Engineering, 2019, 7(1):324-331. [10] Li H S, Wen Y, Cao A S, et al. The influence of additives (Ca2+, Al3+, and Fe3+) on the interaction energy and loosely bound extracellular polymeric substances (EPS) of activated sludge and their flocculation mechanisms[J]. Bioresource Technology, 2012, 114:188-194. [11] 王钧锐. 化纤废水预处理及混合废水达标处理中试研究[D]. 大连: 大连理工大学, 2016. [12] Nawrocki J, Kasprzyk-Hordern B. The efficiency and mechanisms of catalytic ozonation[J]. Applied Catalysis B: Environmental, 2010, 99(1/2):27-42. [13] ?lvarez P M, Beltrán F J, Pocostales J P, et al. Preparation and structural characterization of Co/Al2O3 catalysts for the ozonation of pyruvic acid[J]. Applied Catalysis B: Environmental, 2007, 72(3/4):322-330. [14] 郭彩荣. 非均相催化臭氧氧化处理造纸废水生化尾水的研究[D]. 杭州: 浙江大学, 2017. [15] Konsowa A H. Decolorization of wastewater containing direct dye by ozonation in a batch bubble column reactor [J]. Desalination, 2003, 158(1/2/3):233-240. [16] Gilcreas F W. Standard methods for the examination of water and waste water[J]. American Journal of Public Health and the Nation’s Health, 1966, 56(3):387-388. [17] Badalians Gholikandi G, Zakizadeh N, Masihi H. Appli- cation of peroxymonosulfate-ozone advanced oxidation process for simultaneous waste-activated sludge stabilization and dewatering purposes: A comparative study[J]. Journal of Environmental Management, 2018, 206:523-531. [18] 王正. 污泥臭氧化影响因素及组合工艺污泥减量化效果研究[D]. 哈尔滨: 哈尔滨工业大学, 2008. [19] Zhang J, Zhang J, Tian Y, et al. Changes of physicochemical properties of sewage sludge during ozonation treatment: Correlation to sludge dewaterability [J]. Chemical Engineering Journal, 2016, 301:238-248. [20] 刘亮. 调理剂与臭氧联用对污泥脱水性能影响的研究[D]. 青岛: 青岛理工大学, 2014. |
| 备注/Memo: | 收稿日期:2022-04-27.宁波大学学报（理工版）网址:http://journallg.nbu.edu.cn/ 基金项目:宁波大学大学生科技创新计划项目（2021SRIP1412）. 第一作者:郑洋洋（1994－）,男,河南周口人,在读硕士研究生,主要研究方向:固体废物处理与资源化.E-mail:1537263209@qq.com *通信作者:郭敏辉（1989－）,男,湖南长沙人,工程师,主要研究方向:固体废物处理与资源化.E-mail:guominhui@nbu.edu.cn 宁波大学学报（理工版）网址：http://journallg.nbu.edu.cn/ |
