温度对分光光度法测定超滤膜性能的影响
PDF下载 (19266)胡宁恩,肖通虎 *,邱慧莹,刘雁飞.温度对分光光度法测定超滤膜性能的影响[J].宁波大学学报(理工版),2017,30(4):110-115.DOI:
HU Ning-en,XIAO Tong-hu *,QIU Hui-ying,LIU Yan-fei.Effect of temperature on ultrafiltration membrane performance detected by spectrophotometric method[J].Journal of Ningbo University(Natural Science & Engineering Edition),2017,30(4):110-115.DOI:
| Title: | Effect of temperature on ultrafiltration membrane performance detected by spectrophotometric method |
| 作者: | 胡宁恩, 肖通虎 *, 邱慧莹, 刘雁飞 |
| Author(s): | HU Ning-en, XIAO Tong-hu *, QIU Hui-ying, LIU Yan-fei |
| 关键词: | 温度; 分光光度法; 超滤膜; 聚乙二醇; 截留分子质量 |
| Keywords: | temperature; spectrophotometric method; ultrafiltration membrane; polyethylene glycol; molecular weight cut off |
| 分类号: | TQ028 |
| 文献标识码: | A |
| 摘要: | 以分光光度法中的碘沉淀法为实验体系, 取聚乙二醇(PEG)为标准物质, 考察温度变化对分光光度法测定超滤膜截留分子质量、平均孔径以及孔径分布的影响. 结果表明, 当各个分子质量的PEG质量浓度一定时, 随着温度升高, 其吸光度减小. 温度对高质量浓度区间(>4mg?L-1)PEG吸光度的影响较大, 以PEG宽质量浓度区间(2~10mg?L-1)作标准曲线为基准, 温度升高时, 所测膜截留分子质量显著增加, 平均孔径增大, 膜孔径分布变宽. 温度对低质量浓度范围(<4mg?L-1) PEG吸光度的影响较小, 以PEG低质量浓度区间作标准曲线为基准, 各个温度条件下所测膜截留分子质量、平均孔径及膜孔径分布基本不变. 通过配制低质量浓度PEG溶液作标准曲线或将PEG渗透液稀释到低质量浓度区间进行吸光度测试可减小温度对分光光度法测定超滤膜性能的影响. |
| Abstract: | Based on the method of iodine precipitation, we investigate the effect of temperature on evaluating the molecular weight cut off (MWCO), the mean pore size and pore size distribution of ultrafiltration membrane by spectrophotometric method. The results show that for the certain concentration of PEG solution, the absorbance of PEG gradually decreases as the temperature increases. It is found that the variation of temperature obviously influences the absorbance of PEG under high concentration condition (>4mg?L-1). Based on PEG standard curve in wide concentration range (2-10mg?L-1), the MWCO grows more significantly, while the mean pore size increases and so does the pore size distribution with the temperature increasing. However, the variation of temperature has less effect on the absorbance of PEG under the low concentration condition (<4mg?L-1). Judging by the PEG standard curve in lower concentration range, the MWCO, the mean pore size and the pore size distribution remain almost unchanged at different temperature. The effect of temperature on the ultrafiltration membrane performance detected by the spectrophotometric method can be reduced using PEG standard curve in lower concentration range or diluting permeated solution to the low concentration range before testing its absorbance. |
| 参考文献 /References: | [1] 段文松, 王振中. 超滤膜结构参数特性的分析研究[J]. 江苏环境科技, 2007, 20(02):9-11. [2] 张艳萍, 潘献辉, 王旭亮, 等. 中空纤维微滤膜孔径检测方法研究[J]. 膜科学技术, 2013, 33(3):97-102. [3] 诸爱士, 林贤诉, 高兴. 液—液置换法测试超滤膜孔径及其分布的研究[J]. 浙江科技学院学报, 2004, 16(4):240-243. [4] 吕晓龙. 超滤膜孔径及孔径分布的测定方法I常用测定方法讨论[J]. 水处理技术, 1995, 21(3):137-141. [5] ROSIAH R, MARGARET H, DARRELL P. A refined one-filtration method for aqueous based nanofiltration and ultrafiltration membrane molecular weight cut-off determination using polyethylene glycols[J]. Journal of Membrane Science, 2011, 382:278-290. [6] 罗鸣, 尚闽, 郑祥. 蛋白截留法评价超滤膜分离性能研究[J]. 膜科学与技术, 2014, 34(6):56-61. [7] 张显球, 张林生, 吕锡武, 等. 一种求得纳滤膜截留分子量的方法[J]. 东南大学学报(自然科学版), 2007, 37(5):883-886. [8] 周晨, 陆晓峰, 侯铮迟, 等. 分光光度法和总有机碳法对超滤膜截留性能测定的比较[J]. 膜科学与技术, 2011, 31(5):35-39. [9] 董声华, 田燕杨, 兰娜, 等. 凝胶色谱法测量切割分子量分布表征超滤膜[J]. 水处理技术, 1990, 16(4):323-327. [10] GB/T20103-2006, 膜分离技术术语[S]. [11] CHAKRABARTY B, GHOSHAL A K, PURKAIT M K. Effect of molecular weight of PEG on membrane morphology and transport properties[J]. Journal of Membrane Science, 2008, 309:209-221. [12] XU Z L, QUSAY F A. Effect of polyethyleneglyeol molecular weights and concentrations on polyethersulfone hollow fiber ultrafiltration membranes[J]. Journal of Applied Polymer Science, 2004(1):3398-3407. [13] 冯超群, 杨峰, 陈天缘, 等. 分光光度法测定聚乙二醇水溶液浓度[J]. 工业技术, 2013 (5):126-127. [14] 刘海霞, 张浩勤, 刘金盾, 等. 分光光度法测定不同分子量聚乙二醇浓度[J]. 河南化工, 2004(5):36-37. [15] 俞建君. 对碘沉淀法测定聚乙二醇浓度的改进[J]. 过滤与分离, 2008, 18(4):43-45. [16] HY/T 050-1999, 中空纤维超滤膜测试方法[S]. [17] GB/T 32360-2015, 超滤膜测试方法[S]. [18] 崔厚欣. 吸收光谱法在实际应用中的关键问题的研究[D]. 天津: 天津大学, 2006. [19] RUI C O, CHUNG T S, WIT J S D, et al. Novel cellulose ester substrates for high performance flat-sheet thin-film composite (TFC) forward osmosis (FO) membranes[J]. Journal of Membrane Science, 2015, 473:63-71. [20] SINGH S, KHULBE K C, MATSUURA T, et al. Membrane characterization by solute transport and atomic force microscopy[J]. Journal of Membrane Science, 1998, 142:111-127. |
| 备注/Memo: | 收稿日期: 2016－07－06. 宁波大学学报（理工版）网址: http://journallg.nbu.edu.cn/ 基金项目: 浙江省公益技术应用研究项目（2016C33023）; 浙江省教育厅科研项目（Y201533832）. 第一作者: 胡宁恩（1991－）, 男, 浙江永嘉人, 在读硕士研究生, 主要研究方向: 功能高分子分离膜. E-mail: 979163133@qq.com *通信作者: 肖通虎（1974－）, 男, 江西吉水人, 副教授, 主要研究方向: 高分子水处理膜. E-mail: xiaotonghu@nbu.edu.cn 宁波大学学报（理工版）网址：http://journallg.nbu.edu.cn/ |
