受拉钢筋锈蚀后混凝土箱梁抗剪承载能力研究
PDF下载 (671)叶晗晖,奚 康,葛胜良,布占宇.受拉钢筋锈蚀后混凝土箱梁抗剪承载能力研究[J].宁波大学学报(理工版),2019,32(5):70-77.DOI:
YE Hanhui,XI Kang,GE Shengliang,BU Zhanyu.Shear capacity of concrete girder with corroded longitudinal reinforcing steel bars[J].Journal of Ningbo University(Natural Science & Engineering Edition),2019,32(5):70-77.DOI:
| Title: | Shear capacity of concrete girder with corroded longitudinal reinforcing steel bars |
| 作者: | 叶晗晖, 奚 康, 葛胜良, 布占宇 |
| Author(s): | YE Hanhui, XI Kang, GE Shengliang, BU Zhanyu |
| 关键词: | 纵向钢筋锈蚀; 电化学腐蚀; 抗剪; 混凝土梁; 工字型截面 |
| Keywords: | longitudinal reinforcing steel corrosion; electrochemistry corrosion; shear resistance; concrete beam; I-shaped section |
| 分类号: | U443.22 |
| 文献标识码: | A |
| 摘要: | 为了研究不同服役时间的箱型截面混凝土桥梁上部结构抗剪受力性能和破坏机理, 按1/4缩尺比设计制作了3片剪跨比1.27的工字型截面钢筋混凝土梁. 首先进行纵向受力钢筋恒电流电化学快速腐蚀, 3个试件的受拉纵向钢筋锈蚀率分别为0、10%和20%, 然后用两点加载法在万能试验机上进行抗剪承载力加载试验. 结果表明: 从S1到S3试件, 随着纵向受力钢筋锈蚀率的增大, 梁的峰值荷载降低, 峰值荷载对应的挠度降低, 极限位移降低; 20%峰值荷载以下时S1和S2试件混凝土应变沿高度方向基本满足平截面假定, 锈蚀率较大的S3试件则不满足平截面假定; 非锈蚀钢筋混凝土梁用公预规斜截面抗剪承载力公式计算较为准确, 3种钢筋锈蚀混凝土斜截面抗剪承载力计算方法的结果基本一致, 但随着钢筋锈蚀率增大, 3种方法的计算精度均有所降低. |
| Abstract: | In order to study the shear resistance and failure mechanism of the box-section concrete bridge superstructure with different service time, three I-section reinforced concrete beams with a 1/4-scale ratio of 1.27 are designed and fabricated. Firstly, the electrochemical stress rapid corrosion of the longitudinally stressed steel bar was carried out. The corrosion rates of the longitudinal steel bars of the three specimens were 0, 10% and 20%, respectively, and then the shear capacity was tested on a universal testing machine by two-point loading method. The results show that from the S1 test piece to the S3 test piece, the peak load of the beam decreases with the increase of the corrosion rate of the longitudinally loaded steel bar, the deflection corresponding to the peak load decreases, and the ultimate displacement decreases. S1 and S2 are below the 20% peak load. The specimen concrete strain satisfies the flat section assumption in the height direction, and the S3 specimen with large corrosion rate does not satisfy the flat section assumption. The non-corroded reinforced concrete beam is calculated accurately with the common pre-standard oblique section shear capacity formula. The results of three types of calculation method of the shear capacity of the steel corrosion concrete oblique section are basically the same, but with the increase of the corrosion rate of the steel, the calculation accuracy of the three methods is reduced. |
| 参考文献 /References: | [1] Wang X H, Li B, Gao X H, et al. Shear behaviour of RC beams with corrosion damaged partial length[J]. Materials and Structures, 2012, 45(3):351-379. [2] Azam R, Soudki K. Structural behavior of shear-critical RC slender beams with corroded properly anchored longitudinal steel reinforcement[J]. Journal of Structural Engineering, 2013, 139(12):136-142. [3] Azam R, Soudki K. Structural performance of shear- critical RC deep beams with corroded longitudinal steel reinforcement[J]. Cement and Concrete Composites, 2012, 34(8):946-957. [4] Higgins C, Farrow I W. Tests of reinforced concrete beams with corrosion-damaged stirrups[J]. ACI Structural Journal, 2006, 103(1):131-141. [5] 金伟良, 赵羽习. 锈蚀钢筋混凝土梁抗弯强度的试验研究[J]. 工业建筑, 2001, 31(5):9-11. [6] 惠云玲, 李荣, 林志伸, 等. 混凝土基本构件钢筋锈蚀前后性能试验研究[J]. 工业建筑, 1997, 27(6):14-18; 57. [7] 袁迎曙, 余索. 锈蚀钢筋混凝土梁的结构性能退化[J].建筑结构学报, 1997, 18(4):51-57. [8] 陶峰, 王林科, 王庆霖, 等. 服役钢筋混凝土构件承载力的试验研究[J]. 工业建筑, 1996, 26(4):17-20; 27. [9] 牛荻涛, 翟彬, 王林科, 等. 锈蚀钢筋混凝土梁的承载力分析[J]. 建筑结构, 1999, 29(8):23-25. [10] 薛昕, 杨成. 纵向受拉钢筋锈蚀钢筋混凝土梁的抗剪性能[J].上海交通大学学报, 2016, 50(11):1767-1772. [11] 卫军, 张萌, 董荣珍, 等. 钢筋锈蚀对混凝土梁破坏模式影响的试验研究[J]. 湖南大学学报(自然科学版), 2013, 40(10):15-21. [12] 郭在田. 薄壁杆件的弯曲与扭转[M]. 北京: 中国建筑工业出版社, 1989. [13] Anagnostopoulou M, Filiatrault A, Aref A. Seismic design and analysis of a precast segmental concrete bridge model[R]. Buffalo: University at Buffalo, State University of New York, 2011. [14] Tang L, Utgenann P, Boubitsas D. Durability and service life prediction of reinforced concrete structures[J]. Journal of the Chinese Ceramic Society, 2015, 43(10): 1408-1419. [15] Ou Y C, Susanto Y T T, Roh H. Tensile behavior of naturally and artificially corroded steel bars[J]. Construction & Building Materials, 2016, 103:93-104. [16] 胡俊. 锈蚀钢筋混凝土偏心受压构件试验及其承载力计算模型研究[D]. 长沙: 长沙理工大学, 2010. [17] 江见鲸, 李杰, 金伟良. 高等混凝土结构理论[M]. 北京: 中国建筑工业出版社, 2007. [18] 周氐. 现代钢筋混凝土基础理论[M]. 上海: 上海交通大学出版社, 1989. [19] GB50010-2010. 混凝土结构设计规范[S]. [20] JTG D3362-2018. 公路钢筋混凝土及预应力混凝土桥涵设计规范[S]. [21] Auyeung Y B, Balaguru P, Chung L. Bond behavior of corroded reinforcement bars[J]. ACI Materials Journal, 2000, 97(2):214-220. [22] 何世钦. 氯离子环境下钢筋混凝土构件耐久性能试验研究[D]. 大连: 大连理工大学, 2004. [23] 王雪慧, 钟铁毅. 混凝土中锈蚀钢筋截面损失率与重量损失率的关系[J]. 建材技术与应用, 2005(1):4-6. |
| 备注/Memo: | 收稿日期: 2019－02－20. 宁波大学学报（理工版）网址: http://journallg.nbu.edu.cn/ 基金项目: 国家重点研发计划（2017YFC0702900）; 国家自然科学基金（51208268, 51878606）; 浙江省基础公益研究计划工业项目（LGG18E080004）; 宁波市交通运输科技项目（201507, 201602, 201706）. 宁波大学学报（理工版）网址：http://journallg.nbu.edu.cn/第一作者: 叶晗晖（1994－）, 男, 浙江台州人, 在读硕士研究生, 主要研究方向: 桥梁抗震. E-mail: 15728044697@163.com *通信作者: 布占宇（1977－）, 男, 山东聊城人, 博士/教授, 主要研究方向: 桥梁抗震. E-mail: buzhanyu@nbu.edu.cn |
